Cracking and Splitting in Timber
Posted on by Richard
Summer in general is a complete pain for our industry, it’s at this point we get customers questioning the ‘quality’ of our timber used in some of our products as some cracks and splits start to appear in items that use posts such as play equipment and gazebos.
Thankfully, it’s not just us either, every single supplier of timber products for the garden gets exactly the same thing. See this company explaining the same issue:Taylors Garden Buildings, also have a look at this one: Plum Products.
Summer historically costs the timber industry thousands upon thousands of pounds due to perceived ‘defects’ in timber by customers when 99% of the time no defect exists at all.
Natural Organic Substance.
Timber is a natural substance, we all know that. And, as it is organic, it is greatly influenced by it’s surroundings and more specifically it is trying to reach anequilibrium with it’s natural surroundings.
When a tree is first cut down (green wood) it can contain over 50% of it’s weight in water. This water is naturally contained in the wood and is divided into two categories:
Free Water and Bound Water.
Free Water is water that is held within the wood via capillary action. It can be absorbed and expelled.
Bound water is water within the wood that is bonded via hydrogen atoms.
When timber is dried it will be the free water that is the first to leave.
Before timber is used it is dried when most of the free water is removed (fibre Saturation Point of Wood (FSP)) FSP is achieved at about 25 – 30% moisture content. Wood is dried to it’s natural surrounding environment and as such is engineered to work within it to about 20 – 25%.
Benefits of dried timber.
- Decay organisms generally cannot thrive in wood with a low moisture content. Many wood loving insects can only live in green timber.
- Dried wood has better thermal and insulation properties.
- Preservatives and finishes penetrate better with dried wood.
- Dried wood is generally a lot stronger than green wood.
Equilibrium of the environment
As I’ve mentioned wood wants to be the same as it’s environment both in moisture content and temperature. This is where we start to see a problem, especially during the Summer months and soaring temperatures. The timber starts to exhibit cracks and splits where it further dries out from it’s original point of FSP.
It is, by its nature trying to reach an equilibrium with it’s surrounding air moisture. During summer this moisture content in the air is going up and down all the time as is the temperature and the wood is trying to do the same thing.
Seasonal Wood Shrinkage.
Regardless of how well dried a piece of wood is it will always grow and shrink according seasonal changes in relative humidity of the air.
Changes in ambient humidity is all that is needed and will always affect timber regardless of any other influences.
A good treatment can slow this process down greatly regulating how fast moisture gets in and out of the timber. Wood shrinks by different amounts in different directions, there is however very little movement in the grain lengthwise. There is some shrinkage radially and a greater amount tangentially (along the curvature of the growth rings).
Here’s a picture of my gate post at home, the weather we’ve been having is having a major impact on it. You’ll notice that cracks and splits are appearing and will continue to do so at different rates. Most of the splits are occurring perpendicular to the growth rings because there is more shrinkage along the direction of the rings. At the moment this piece of timber is still drying to reach an equilibrium with it’s surroundings, the inner core is wetter than the outer but once that has dried to the level of the atmosphere virtually all these splits will dissapear.
Cracked and Splitting timber
Here’s another basic but extreme example. Because of the different rates of radial and tangential shrinkage, distortion of the wood can occur. It can also cause radial cracks from the centre of the wood to the outer edge. This is because the circumference shrinks more than it’s radius and a big radial crack appears allowing the circumference to shorten.
Shorter circumference resulting in a radial crack
Here’s my post again showing a crack top to bottom, this is a radial split as above and will close up once the whole of the post has reached an equilibrium either by further drying or expansion as the moisture in the air increases such as Autumnal weather.
Longitudinal crack along the radius of the grain.
Here’s another example, this is a crack that’s just starting to emerge, they can appear very quickly during a hot day and often after installation if exposed in the hot sun or stored in a hot environment such as a garage.
Gazebo Post Crack starting to appear.
The same thing happens to furniture when out in the sun or a change of humidity. This is the timber from my picnic table I photographed yesterday, you’ll notice small cracks are just starting to appear.
Cracks starting to appear in the top of a picnic table.
Round poles such as the type used in many play centres, swings and climbing frames also exhibit the same properties and often far worse:
Round pole split along the radius
What is mainly affected?
The properties exhibited here are mainly found in products that utilise posts such as our gazebos and outdoor play equipment.
This is because the posts are made from a whole tree trunk. You can see that very clearly with my fence post as an example, this was not supplied via Tuindeco but by a local fence supplier, our posts however will be the same. This post has been in the ground for about 12 months and supports a gate.
This post is encompassing both the ‘Heart’ and the ‘Pith’ of the tree and as such it shrinks and swells at different rates. A whole tree trunk is used as it is considerably stronger than the outside of the tree, If we were to use the outside then we would lose a huge amount of strength, the strongest part of a tree of course is the heart.
As I’ve said and we all know, wood is an organic substance. It also tries its hardest to match it’s environment which you may not know.
It moves, swells, and shrinks to do so and is normal timber behaviour.
This should be fully understood and expected when buying any timber product for your garden. Sometimes these cracks can open up alarmingly large but remember it is entirely normal and once the inner core has dried the crack will close up. Likewise as the moisture in the air increases so will the free water absorbed by capillary action in the wood and once again the cracks will close up.
None of these splits or cracks in the timber will affect it’s structural integrity or inherent strength.
If however, it concerns you I recommend the use of a good quality timber treatment as this will restrict the moisture both entering and leaving the wood.
Basically timber can be viewed as a bit of a pain!
Customers sort through the DIY shops, they buy gazebos or other ‘post’ style products and immediately reject them as being defective, this is simply not true!
Wood, by definition cannot be defective, there is nothing to go wrong other than obvious rot which is very rare in graded timber.
If you experience cracks and splits in your timber, especially when it is obviously milled from a whole trunk it is not a ‘defective’ product, nor is the strength impaired, it simply is timber exhibiting it’s normal state and characteristics.
Enjoy it and embrace it as it is part of it’s charm and warmth we all enjoy. Watch it and marvel at it’s behaviour, cracks and splits will dissapear, open up, wander and move …. is it really a pain or a bloomin’ clever feature of a very basic material we all love? If you don’t like it, treat it with a good timber treatment and restrict the flow of moisture in and out. However! Even the best treatments allow moisture transfer, even plastic does to a certain extent.
The ONLY thing to remove the transfer of moisture is aluminium as found in crisp packets! Cover your posts in this and they will never crack or split!
Update: 11th August 2013
I’m going to try and prove my own waffle, I’m going to focus on my fence post, bear in mind it’s been in the ground for about a year and I’m now going to try and study it.
I plan to photograph it over the weeks, months and maybe years ahead. It’s all very well me spouting on about the theory. Some may even see it as excuses for a dodgy bit of timber so lets actually see what happens with this post over time if at the end I’m a liar I apologise. This is going to be interesting ….. as far as a bit of wood can be …
I’m also going to find a brand new post from one of our Gazebos, stick it in the ground and see what that does as well, for now, my fence post …..
This picture is dated 5th August:
August 5th, split fence post
Updated picture, today, 11th August 2013
Split post taken on 11th August
Some of the radial lines looks smaller to me, or am I just imagining them? The split at almost 12 o’clock is smaller.
There’s changes but nothing has really closed up.
The week’s weather has had some rain, a couple of storms but not massive amounts, it’s still been pretty warm. Lets see what the next week or two does to it.
The next time I’ll keep the camera back like the picture above so we can really see the changes ….. if any … or at least compare them better.
A huge change since the last time I looked at the post. You can really see the change this time and most of the splits have closed up. Both the heart and the pith are reaching an equilibrium. Clever stuff wood!
The cracked post a few months on. This pictures is dated 29.10.13
The splits that were showing in the side of the post have almost gone as well.
Fence post cracks are almost gone compared to the summer months.